I wasn’t expecting to have the plumber in this early in the game

As I said, the best place in the house for our new woodburning stove was occupied by a large cold-air intake duct for the furnace. We needed a plumber to move the vent over a few feet. “Piece of cake,” as we were told. Well, he needed a carpenter, too. We were already covered there. Ditto for the electrical.

In addition, as I’ve explained, the best pathway for the wood stove’s metal pipe chimney ran right through a cubbyhole where our water heater sat. We were already intending to replace the unit for a more efficient heat-exchange model anyway, so we bumped that up in the timeline. As long as the plumber was in, right?

And while Thomas was at it, the float on our old, jerry-rigged sump pump had begun sticking, causing the cellar to flood, so that could go, too. No problem, he’d replace that at the same time.

If we like him, there’s a lot more ahead – a kitchen remodel, a new bathroom upstairs, and then remodeling the little one downstairs that’s way too outdated. Oh, yes, and the outdoor faucets.

Its pad was installed earlier.

So that’s how the heat-exchange water heater was installed in the cellar, under the old, inefficient water heater. Adam, our contractor, handled the new concrete footer and the electrical wiring. We’re told it should also dehumidify our cellar. Now that’s a happy bonus!

And all this was wrapped up the day before Christmas Eve.

Why do people want to know about writer’s workroom?

Is it even a sanctuary? I call mine a studio, while my spouse refers to it as my lair.

In my first four apartments, mine was in a corner of a room, including three where I sat cross-legged. (Not an option any more, thanks to aging. The sitting on the floor, I mean.) The fourth had a circular utility spool on its side as a table and some kind of chair. If you don’t remember that piece of hippie furniture, just ask.

In later moves, I rented apartments having a second bedroom I could dedicate to the Real Work.

The most impressive was in the small townhouse, where my dream studio occupied the only bedroom upstairs. With its hanging ferns, it looked pretty impressive – from the street, especially, I configured the downstairs into a comfy studio apartment.

There’s the question about sitting in front of a window, providing some kind of view. Annie Dillard, for one, has weighed in totally against that, preferring concrete blocks. At the other extreme, I remember overhearing one wannabe writer detailing to her husband all of the remodeling that was to be done to their house so she could take up writing the novel she planned.

I’ve had both. My office chair in the townhouse gave me a commanding view of the parking lot and water tower beyond. Well, the arrangement gave me a feeling of command, period. In my second apartment in Baltimore, my studio overlooked a set of AM radio towers but my desk stared straight into a wall. The first had looked down on some small urban backyards and an A&P grocery beyond an alley.

Once I moved to Dover and remarried, I wound up in the north half of the third floor, under the eaves, as you can see in previous posts here at the Red Barn.

At the moment, I’m in a corner of my bedroom, in front of a window and our backyard. Once our renovations are finished, I’ll be upstairs but with the window further above me.

Since I’m pretty much paper-free these days, I need far less tabletop and filing cabinets – remember those? You can’t even give them away any more. They’re rather like used pianos.

Well, one friend gets a new chair for each new book, sometimes nothing more than an aluminum lawn chair, and he’s done quite well, getting reviewed in both the New York Times and its Sunday book section or magazine and sometimes showing up on the bestseller list.

What’s usually overlooked is the supporting space – filing cabinets (yes, a few remain), bookshelves, tables, additional seating, even a daybed or couch, perhaps. Dillard, I recall, had some kind of cube. I think fondly of a Mainer who had the top half of a small barn remodeled for his library and cozy reading and writing space – it was the inspiration of what I hoped to do to our red barn, a dream that never quite materialized.

One big transformation for me has been the shift from paper to digital. I mean, I rarely print out anything anymore. For a while, I didn’t even have a printer. And, when I was up on the third floor, our printer was down on the main floor, accessible to the rest of the family. That wireless connection was a huge advance over the proprietary cord attachment.

I require far less room now than I did when I dreamed of converting the top of my red barn into a studio and library. My, that was grandiose! I hate to think what the heating bill would have been, just for starters. And besides, once we went from five to two in the household, the entire equation changed.

~*~

Equally fascinating is a writer’s use of time.

Charles Bukowski insisted on daily “butt time” at the keyboard, while Jack Kerouac would charge up for a two-week mostly sleepless typing orgy every six months or more.

I’ve known both but lean more these days toward Bukowski.

For much of my adult life, I felt guilty for the reality that writing took away from so many other things I “should” be doing. It was somehow selfish. One summer, though, at a Quaker gathering on the Bowdoin College campus in Maine, I was in a workshop on prayer. The facilitator handed us each a card and told us to write a prayer request – for something for ourselves. For most of the circle, maybe all, this came as a shock. We were prepared to pray for world peace or people we knew, but not ourselves.

So we broke out into groups of three or four, and prayed for each other’s requests. To my surprise, I felt liberated. One participant told my writing was my gift and to respect that. It made it much easier for me to dedicate one day a week to my writing efforts – I was on a four-day workweek at the time, but managed to continue that focus after going back to the traditional five.

~*~

My productive time in college was after midnight. After living in the ashram, that shifted to dawn. During my sabbatical, it was two stretches – one roughly 10 am to 2 pm and then after 10 pm to whenever.

I had big daily and weekly schedule plans for my retirement years, but now that I’m there, those are either amusing or embarrassing. I spend way too much of my life at this laptop, let’s simply say.

Remember, Internet and blogging weren’t a factor back when I was dreaming of being free of the daily office.

Earlier in this series I touched on authors who said they wrote only two or four hours a day and my shock that it wasn’t more.

Now, though, I’m seeing that in a different light. In my time with the newspaper syndicate, my “productive” time was a mere hour-and-a-half to two hours a day when I called on editors in person. The rest of the time was travel, preparing for the sales call, following up with phone calls and letters, filing expense and mileage reports along with reactions – what I term infrastructure. It’s a pattern I see as more common than the assembly line productivity that’s somehow instilled in me. You know, the reaction when you see a Road Work sign and then see three guys doing nothing more than smoking a cigarette.

Or, as I realized when I was stationed in the composing room on a Saturday night and moving pages for the Sunday editions, I more than earned my week’s pay in an hour-and-a-half as we raced to meet deadline. It was a furious crush. If those papers weren’t in supermarkets or readers’ homes across the state on time, we’d lose sales and subscribers.

In other words, you can’t go by assembly-line wage thinking.

As an added complication, we were getting a woodburning stove

Considering the frequency and length of electrical outages in Maine, having an emergency heat source in place was a high priority. I’ll explain later what derailed us from going directly from an emergency generator. Wood heat was the more obvious answer for us, but the big obstacle was that we didn’t have a usable chimney. We couldn’t just run up to Tractor Supply or Tru-Value, pick out a cast-iron stove, plug it in, and breathe a sigh of comforting relief.

Instead, we needed some professional advice, and that’s where we were stymied. Local inquiries led nowhere. The nearest wood stove and fireplace dealers were 2½-hour drives away.

Since Ellsworth has two, that’s where we headed. The smaller dealership was far more helpful than the other – and it referred us to a nearby chimneysweep who, after we approached him, did agree to install a stove for us as well as, more crucially, addressing the chimney situation.

While a previous woodburning cook stove in the kitchen had vented into the same flue that the furnace uses, that’s now contrary to building code.

Tim confirmed that our best smoke-venting option was to run an insulated metal chimney pipe straight up next to the existing brick one. At this point, with our upstairs about to be torn apart and the rafters exposed, we wouldn’t be disrupting anything there. Our ultimate placement of the stove itself would require moving a water heater and a cold-air vent in the floor. Not that big of an issue, now that we had a contractor. Glory be!

As for the existing but inefficient hot water heater? That advanced our planned acquisition of a heat-exchange water heating unit, but just where?

That’s when Adam, our contractor, lined up a license plumber, Thomas. You’ll be meeting more of him later.

~*~

Back to the central decision, which stove?

From my days in the Pacific Northwest, I was impressed with the pioneering Norway’s Jotul brand, a view reenforced by our purchase and intensive use of a small model in New Hampshire two decades ago.

Still, looking for maximum efficiency of our new stove, I was pressed to research other available options. After all, a lot has happened in the interim. And how, as I discovered.

Since our stove was also for a power-outage alternative and not just supplemental heat, wood pellets were out of the question. Alas, perhaps. A pellet fire isn’t quite the same when it comes to simple repose.

Two new considerations for me were cast-iron versus straight metal. The former takes longer to warm up but holds longer. The latter, the opposite.

Since much of our usage Way Downeast involves offseason chilly mornings and evenings in spring and autumn, the metal models gained an advantage over cast iron. We’ll see how that holds.

A complicating factor was catalysts, which would require attention every few years – and, more critically, by whom? By this point, Jotul slipped from the picture.

From my book Quaking Dover, I knew that soapstone and other heat sustainers worked as efficiency boosters, but in this round, the added cost and weight didn’t fit our setting.

Vermont Castings, which had been our principal rival to Jotul, fell from consideration over quality control issues, as other, newer, brands came to the fore: Ambiance, Blaze King, and HearthStone, among them.

We did have to quibble about how our stove would look and function in our situation, but in the end, after a thorough review of the efficiency specs, sizes, and prices, we went with a Lopi model, one from an enterprising Pacific Northwest outfit.

Alleluia. We even got it installed before deep winter kicked in.

Second floor.

A view up the pipe before it was capped.

Meanwhile, on the ground floor.

And there it was, just in time for Christmas.

~*~

Let’s be honest. The new stove wasn’t entirely about emergency heating. It was mostly about having the utter pleasure of wood warmth. It was even about reducing our onerous fuel oil bills, even before we add heat-exchange units upstairs.

After waiting three years to get the renovations underway, the unfolding events sometimes felt chaotic. So much happened at once.

Still, looking at the glossy brochures, I’m left thinking there’s a much bigger picture left to be presented. Sitting back against the unrivaled comfort of a wood fire and reading in my favorite chair is an unsurpassed pleasure in my book. This was a definite improvement over our previous winters.

As a slide flash, as a writer I’m reminded about the adage, “Write only about what you know.” Is there anything like this in a novel? Or even a movie? Maybe the bearskin rug in front of a fire as a photo?

By the way, we never heard back from the other stove dealership. The bigger one. We do have an affinity for smaller is beautiful, especially when it’s family-centered.

Next up, a set of chain-reaction decisions

The roofing wasn’t the only thing taking place. We had to make some more key decisions regarding the next steps.

First was settling on the size and shapes and placement of windows in the back half of the house. We’ll examine those later. The glossy catalogues had a wide range of types and sizes, but no prices. For now, Adam needed to know where to frame them.

To do that much, we had to finalize our upstairs layout, at least roughly. A new bathroom and laundry room were part of that, details to come later.

Getting that far included electrical outlet placements along the exterior walls.

Those were steps that had to be taken before the spray-foam insulation crew showed up – which they did, two days after promised and leaving us with a nonrefundable Airbnb reservation. On top of that, we were required to be out of the house for 24 hours after they finished. Back to the Airbnb reservation. The crew’s deadline here was also contingent on a bigger job they were doing downtown – the two brothers live an hour-and-a-half from Eastport. We were second in line.

Before.

And after. Note that a diamond window in the corner is no longer in the plan.

Ten recent tools that greatly changed carpentry jobs

Remember, not everyone who carries a hammer is a carpenter.

Apart from the Amish, who often are master carpenters, today’s tradesmen are indebted to these advances:

  1. Rechargeable batteries for all those power tools.
  2. The Sawzall. Top of the list. Any project working on an older house requires getting through earlier construction. This chews right through the mess.
  3. Oscillating multitask tool. The Sawzall’s little sister. Chews through the finer details. It’s like the equivalent of laparoscopic surgery that doesn’t leave huge scars.
  4. Carbide blades. They go right through nails and screws and greatly outlive their earlier incarnations. Think time of constantly replacing the blades as well as the time and cost.
  5. Laser-light “stick.” (And before that, the retractable metal measuring tape.) Look, our contractor’s working with 1/16-inch tolerances. Accuracy counts, especially when dealing with hand-hewn beams and posts from nearly two centuries earlier. He’s trying to get a plumbline precision to preserve the earlier let’s-hope-it-works construction.
  6. Laser level indicator. This one really blows me away. Place the small device where you want and it shows an appropriate line all around. I have no idea how you’d accomplish the measurements otherwise, but they can be crucial. Especially when we’re dealing with everything that’s overhead.
  7. Structural fasteners. They’re engineered to be superior to earlier long screws or bolts. I guess it’s kind of like those zip-ties I’ve come to rely on in gardening, but I’m told this is huge.
  8. Cell phone, including Internet access. You know, YouTube advice, as well as ordering online or by phone, calling consultants, even checking on the status of other participants in the project. Not all of those calls are personal, not that I’d begrudge a hard-worker there.
  9. Clear plastic sheets and zipper strips. A lot of dust and whatever goes flying around, after all. Keeping it rounded up is definitely appreciated, especially as we’re trying to live in the same house. Add to that the power vac. Maybe it’s a guy thing, but these are amazing. Even with water.
  10. Dumpster. I’m starting to see having one outside our house as a kind of status symbol.

Status symbols? We could do a whole other Tendril about those pickup trucks and trailers or the guys’ preferred brands.

Source: Mostly Adam Bradbury.

Weatherproofing the new exterior came next

We now faced some related decisions, beginning with the kind of roofing.

Our preference was for standing seam metal, but we were concerned about the price. It would, however, allow for a lesser roof pitch, and that would give us more headroom, and that was in addition to its added durability.

Asphalt shingles may be less expensive, but we live in a heavy winds-prone town. The forecast seems to have gale warnings every other day, at least for small craft out on the water. After a strong storm, the streets and yards are littered with blown-away shingles, even from new houses.

As I said, living beside the sea exposes us to a lot of wind.

~*~

The next decision involved the color. There were more standard color options than I’d thought from casual observation.

We liked bright red and the bold cobalt, at least for homes out in the country, but ours is tucked into a tight neighborhood and we wanted to continue to blend in. Our goal was something subtle but still classy. The color of the metal would also determine the shade of trim we would be applying later, maybe around the foundation, too.

We settled on a pale blue, which we find is common around the neighborhood.

There was far more to do up there than we could see from the street, and far more steps than simply putting the metal sheets down.

With condensation as a consideration, a vapor barrier went up. Strapping and rigid-foam insulation boards were fitted and secured. A weather-resistant fascia went around the trim. As did flashing.

And finally, we had the metal roofing itself.

After several setbacks from bad weather, Adam and Keith worked like maniacs over the weekend to have it securely in place before a hurricane-force storm – and then Christmas, a storm of a whole other nature.

~*~

As for the exterior walls, new cedar shake shingles were a given.

Extending the back wall, at last

Week 7 brought the dramatic steps that would be seen from the street. This is a small town, after all, and people would talk. Fortunately, all we heard was approval and admiration.

As another plus, the weather turned in our favor, a week without rain.

As an added blessing, Adam, our exacting contractor, was joined by Keith, a simpatico master carpenter (even mediocre ones are hard to find around here). Fortuitously, they melded into a relentless team that raised the back wall, crafted new rafters, and encased the roof like clockwork.

Doing that precisely to an old freeform house like ours required many adjustments akin to sculpting, which these two performed with great understanding and patience.

The new wall would be sitting atop an old wall that was serpentine in length and height. It required a lot of precise correction.

The week ended with the thrill of seeing back half of our greatly expanded upstairs actually buttoned up days before Thanksgiving and the wintry weather to follow.

The front half will have to wait till spring, but there’s plenty to do before then. Much more, actually, than I wanted to consider.